GHG14 ACM2. 1 Fault Codes Circuit Fault Rationality Fault Engine Protection Fault Component Broadcasted Fault Communication Data Fault Information Fault. SPN 108. FMI 13. 110. 158. 168 168 171. 0 1 13. 190. 513. 625. 625 1033. 9 2. 1761. 1761. 1761. 1761 1761 1761 3031. 9 18 31 3. 3031. 3031. 3031. 10. 3031 3056. 19 2. ACM2.1 FAULT CODE …SPN 27 - EGR Valve Position Circuit Fault SPN 27/FMI 3 SPN 27/FMI 4 SPN 27/FMI 7 SPN 51 - Intake Throttle Valve Above or Below Normal Operating Range SPN 51/FMI 2, 3 or 4 SPN 70 (CPC) - J1939 Park Brake Switch Signal Erratic or Missing SPN 70/FMI 13 SPN 70/FMI 19 SPN 84 (CPC) - J1939 Wheel-Based Vehicle Speed Signal Erratic or Missing SPN 84/FMI 13 SPN 84/FMI 19 SPN 84 - Vehicle Speed Sensor ...To use the table below, first write down the SPN and FMI codes you received from the engine diagnostic gauge. Locate each SPN in the first column and its associated definition to the right in the second column. In the same way, locate the FMI in the forth column and its associated definition to the right in the fifth column.Page 281 MBE 4000 DDEC VI TROUBLESHOOTING GUIDE [a] If the voltage is between 4.5 and 5.5 volts, contact the Detroit Diesel Customer Support Center (313–592–5800) for authorization to replace the MCM. [b] If the voltage is less than 4.5 volts, refer to section 27.3.1, step 5.It’s an SPN 656 . Return to Top | find. reply reply. 10-07-2020, (Subject: Engine fuel 1 injector cylinder 6 fmi 7 ) Post: #2. Godsplan15 Established (0 Likes) …This spn fmi codes help explain the underlying meaning of the numerical components which build an engine fault code. - This is not a comprehensive list, or an alternative to the …It’s an SPN 656 . Return to Top | find. reply reply. 10-07-2020, (Subject: Engine fuel 1 injector cylinder 6 fmi 7 ) Post: #2. Godsplan15 Established (0 Likes) …DTC_SPN_InjEnbl6 656 DTC_FMI_InjEnblShortHigh 3 DTC_FMI_InjEnblShortLowOrOpen 5 DTC_SPN_InjEnbl7 657 DTC_FMI_InjEnblShortHigh 3 DTC_FMI_InjEnblShortLowOrOpen 5 ... DTC_FMI_Misfire 7 DTC_SPN_MisfireRandom 65599 DTC_FMI_Misfire 7 DTC_SPN_NonEtcTps 51 DTC_FMI_NonEtcTpsHigh 3 …SPN 656, FMI 6 - Injector Driver #6. Page 107 and 108: SPN 657, FMI 5 - Injector Driver #7. Page 109 and 110: SPN 657, FMI 6 - Injector Driver #7. Page 111 and 112: SPN 658, FMI 5 - Injector Driver #8. Page 113 and 114: SPN 658, FMI 6 - Injector Driver #8. Page 115 and 116: 2) Emissions are higher than allowe.DTC_SPN_InjEnbl6 656 DTC_FMI_InjEnblShortHigh 3 DTC_FMI_InjEnblShortLowOrOpen 5 DTC_SPN_InjEnbl7 657 DTC_FMI_InjEnblShortHigh 3 DTC_FMI_InjEnblShortLowOrOpen 5 ... DTC_FMI_Misfire 7 DTC_SPN_MisfireRandom 65599 DTC_FMI_Misfire 7 DTC_SPN_NonEtcTps 51 DTC_FMI_NonEtcTpsHigh 3 DTC_FMI_NonEtcTpsLow 4 DTC_FMI_NonEtcTpsSkewedHigh 0To use the table below, first write down the SPN and FMI codes you received from the engine diagnostic gauge. Locate each SPN in the first column and its associated definition to the right in the second column. In the same way, locate the FMI in the forth column and its associated definition to the right in the fifth column.180 Jan 25, 2013 0 2012 Freightliner Cascadia ISX Cummins. I keep getting theses SPN fault codes: 651, 652, 653, 654, 655, 656. FMI 7 Injector Cylinder #1,2,3,4,5,6 The injector fuel flow is lower than expected. Fuel filters replaced, Fuel rail pressure sensor replaced, ECM codes cleared.SPN:651 FMI:4 Injector 1 open coil - short circuit ... SPN:656 FMI:5 Injector 6 open coil - open circuit SPN:3659 FMI:4 Injector 1 close coil Œ short circuitMay 20, 2021 · spn 656 fmi 7 cummins also im getting bad mpg I get the same code, it comes and goes. I think there called ghost codes. My mileage sucks to, the best I’ve ever gotten out of my isx 15 is 6.8 and was running lite. When I’m heavy, 5.5. Diesel Dave, Nov 6, 2021 No: Program ECM with most recent calibration. After repairs are complete, retest for SPN 651 – 658 FMI 18. Step 2. Determine if a base engine problem is causing fault code to become active. Decision. Using Electronic Service Tool (EST) with ServiceMaxx™ software, perform the following steps: Key ON, clear codes.Yes: Repair SPN 132 FMI 11, 13 and 14 (refer to diagnostic manual and IK1200526. After repairs are complete, retest for SPN 5397 FMI 31. No: Go to step 3 StepAction Decision 3 Using Electronic Service Tool (EST) with ServiceMaxx software, check Diagnostic Trouble Code (DTC) list for SPN 3251 FMI 2, 3 and 4 (DPFDP/outlet pressure).SPN 1274, FMI 5 - Spark Coil #7 Pri. Page 13 and 14: (Industrial, Smart/Logic Coil) LED . Page 15 and 16: 2nd Page of Diagnostic Information . Page 17 and 18: Resetting active and previously act. ... SPN 656, FMI 6 - Injector Driver #6; Page 107 and 108: SPN 657, FMI 5 - Injector Driver #7;Jul 11, 2020 · ECM SPN 641, Engine Variable Geometry Turbocharger (VGT) Actuator 1 – MID 128 SID 27. FMI 7 • Mechanical system not responding or out of adjustment • Mechanical problem with the Engine Variable Geometry Turbocharger (VGT) actuator • MIL illuminated • Yellow Check lamp illuminated • Low boost and smoke • Possible engine derate • Power loss in some cases when actuator motor has ... SPN: 656 FMI: 7 Description: Injector Solenoid Driver Cylinder 6- Mechanical System Not Responding or Out of Adjustment Troubleshooting: Circuit Description The ECM uses diagnostic software to verify injector operation. During selected conditions, each injector is fired. The fueling quantity and timing are then compared to a specified threshold.During this time, fault code SPN 651 FMI 7 may set. This code may or may not be true. Proceed with the following steps in order to determine if a true injector issue is present or not. 1. If fault code SPN 651 FMI 7 is present, perform a cold idle or hot idle CPA Tool snapshot in order to insure all 6 injectors are working properly. 2.SID, PID FMI SPN Imf Description; 111 Red: ... 656 5 № Nozzle Control Valve chain 6-chain breakage: 328 Yellow: S152 7: 1348 7: Injection VALVE № 2 pump ...Oct 26, 2019 · SPN 656/FMI 3 - EPA10 - GHG14 This diagnostic is typically Injector Cylinder #6 Needle Control Valve Abnormal Operation (MAX).This is normally a problem with number six injector. As long as the wiring and connector pins going to your injector from the ECM all check out good, replace the faulty injector. SPN 656, FMI 6 - Injector Driver #6. Page 107 and 108: SPN 657, FMI 5 - Injector Driver #7. Page 109 and 110: SPN 657, FMI 6 - Injector Driver #7. Page 111 and 112: SPN 658, FMI 5 - Injector Driver #8. Page 113 and 114: SPN 658, FMI 6 - Injector Driver #8. Page 115 and 116: 2) Emissions are higher than allowe.Oct 21, 2021 · The check engine light is back with 2 codes SA O/SPN 656/FMI. The check engine light is back with 2 codes SA O/SPN 656/FMI 18 & SA 150/ SPN 524285/FMI 14. It gives me no info on these codes. … read more. File: 656-t06-27546 Aftertreatment DPF differential pressure sensor stuck in-range Page 7 of 12 Solution: S00000793 Verification Conditions • Turn keyswitch ON. • Connect the recommended Cummins® electronic service tool or equivalent. Action • Use the recommended Cummins® electronic service tool or equivalent.SPN 1327, FMI 31 - Emissions/Catalyst Damage Misfire Detected . Cylinder #5 . Diagnostic Aids . NOTE: If any other DTCs are present, diagnose those first. ... 104 SPN 656, FMI 6 - Injector Driver #6 Short-To-Power; 105 SPN 656, FMI; 106 SPN 657, FMI 5 - Injector Driver #7 Open/Short-To-Ground;1. MIL 2. CEL ENGINE REACTION: Derate 25% VERIFICATION: Engine Idle: One minute. NOTE: Submit completed diagnostics with warranty claim. PROBABLE CAUSES: 1. Bent pins. 2. Spread pins. 3. damaged connector seal. 4. Faulty rear fuel injector harness. 5. Faulty injector with the out-of-range resistance. 6. Corroded pins. 7. Unseated pins. 8.SPN 654 FMI 5 - Cummins FC 332 Injector solenoid driver cylinder 4 circuit current below normal or open circuit SPN 655 FMI 5 - Cummins FC 323 Injector solenoid driver cylinder 5 circuit current below normal or open circuit IK1201447 -Cummins B6.7 Injector Short Circuit Page 1 of 2 7 (*) Denotes Cense Fault codes (**) HHP QSK45/60/78 Fault Severity Levels: Level 1: Stop Engine Now Level 3: Repair at Next PM Level 2: Repair Engine Same Day Level 4: Information Only FAULT CODE (LAMP) SID(S) PID(P) FMI SPN FMI DESCRIPTION QSB QSC QSL9 QSM1 1 QSX1 5 QSK19 QSK23 QS T 30 QSK45 QSK60 QSK78 HHP Level Number (**) 261 (Yellow) P174 ... 2014 International maxxforce 13. I have an issue injector bank 1 &2 SPN 2797 fmi (11). SPN 2798 FMi (11)Spn 1027 fmi (5)Spn 652 fmi (16)We checked and tested all the harness there is 0 resistance … read moreTel./Faks. (0361)222544. Situs web. www .sman7denpasar .sch .id. Moto. SMA Negeri (SMAN) 7 Denpasar, merupakan salah satu Sekolah Menengah Atas Negeri yang ada di Provinsi Bali, Indonesia. Sama dengan SMA pada umumnya di Indonesia masa pendidikan sekolah di SMAN 7 Denpasar ditempuh dalam waktu tiga tahun pelajaran, mulai dari Kelas X sampai ...SPN 656 FMI 5 Injector Driver #6 Open/Short To Ground 107 SPN 656 FMI 6 Injector Driver #6 Short To Power 109 SPN 657 FMI 5 Injector Driver #7 Open/Short To Ground 111 SPN 657 FMI 6 Injector Driver #7 Short To Power 113 SPN 658 FMI 5 Injector Driver #8 Open/Short To Ground 115 SPN 658 FMI 6 Injector Driver #8 Short To Power 1171 Indmar MARINE ENGINES Service and Diagnostic Manual For Electronic Fuel Injection Systems With Indmar Electronic Control Module Version 1.2 Indmar Products Company, Inc Old Millington Road Millington, TN Draft Rev. A-Jan 2008. 2 This Page Intentionally Left Blank. 3 SPN Codes and Page Numbers Sorted by SPN SPN FMI Description Page # …SPN 656 - FMI 5 (Fault Code 325) SPN 654 - FMI 5 (Fault Code 332) Blog.Teknisi. Subscribe to receive free email updates: 0 Response to "SPN 653 - FMI 5 (Fault Code 324)" Post a Comment. Newer Post Older Post Home. Subscribe to: Post Comments (Atom) Categories. Fault Codes CUMMINS ISB ISC ISL ISBe ISDe and …SPN 656, FMI 5 - Injector Driver #6. Page 105 and 106: SPN 656, FMI 6 - Injector Driver #6. Page 107 and 108: SPN 657, FMI 5 - Injector Driver #7. Page 109 and 110: SPN 657, FMI 6 - Injector Driver #7. Page 111 and 112: SPN 658, FMI 5 - Injector Driver #8. Page 113 and 114: SPN 658, FMI 6 - Injector Driver #8. Page 115 and 116:Feb 3, 2021 · SPN 656 / FMI 3 - EPA10 - GHG14 This diagnostic is typically Injector Cylinder #6 Needle Control Valve Abnormal Operation (MAX).This is normally a problem with number six injector. As long as the wiring and connector pins going to your injector from the ECM all check out good, replace the faulty injector. For further confirmation you could ... DDEC FOR MBE900 AND MBE4000 Description Grid Heater Open Circuit Grid Heater Shortened to Ground Grid Heater Special Instructions Grid Heater Defect Vehicle Speed Sensor Anti-tamper Fault 2 Vehicle Speed Sensor anti-tamper Fault 3 Vehicle Speed Sensor not Plausible Adaptive Cruise Control Fault Accelerator Pedal Voltage Above Normal or …SPN 656, FMI 6 - Injector Driver #6. Page 107 and 108: SPN 657, FMI 5 - Injector Driver #7. Page 109 and 110: SPN 657, FMI 6 - Injector Driver #7. Page 111 and 112: SPN 658, FMI 5 - Injector Driver #8. Page 113 and 114: SPN 658, FMI 6 - Injector Driver #8. Page 115 and 116: 2) Emissions are higher than allowe.During this time, fault code SPN 651 FMI 7 may set. This code may or may not be true. Proceed with the following steps in order to determine if a true injector issue is present or not. 1. If fault code SPN 651 FMI 7 is present, perform a cold idle or hot idle CPA Tool snapshot in order to insure all 6 injectors are working properly. 2.File: 656-t06-2771 Page 1 of 16 ISX15 CM2250 Fault Code: 2771 | SPN: 3226 | FMI: 9 Aftertreatment 1 Outlet NOx Sensor - Abnormal Update Rate 1 Check for primary fault codes 2 Low battery voltage 2.1Battery load test 2.2Fuse/distribution panel check 2.3Ground inspection 3 Aftertreatment outlet NOx sensor has incorrect voltageSPN-656-FMI-5 · SPN-656-FMI-6 · SPN-637-FMI-11 · SPN-637-FMI-13 · SPN-644-FMI-8 · SPN ... SPN-3487-FMI-7 · SPN-3473-FMI-31 · SPN-3474-FMI-31 · SPN-3530-FMI-31 ...Detroit Diesel Ddec Vi Mbe900 Troubleshooting Guide DETROIT-DIESEL3 thg 1, 2017 ... Proceed to step 7. 7 Loosen the set screw for the pressure ... FMI number reveals the type of failure that has occurred. Comparing the ...ECM SPN 641, Engine Variable Geometry Turbocharger (VGT) Actuator 1 – MID 128 SID 27. FMI 7 • Mechanical system not responding or out of adjustment • Mechanical problem with the Engine Variable Geometry Turbocharger (VGT) actuator • MIL illuminated • Yellow Check lamp illuminated • Low boost and smoke • Possible engine derate • Power loss in some cases when actuator motor has ...2015 Volvo with ISX 15 engine I have issue with check engine light coming on for injectors spn 656 fmi 7 but when I changed the injector it just changed the code to spn653 fmi 7. At the beginning I ch … read moreNo: Program ECM with most recent calibration. After repairs are complete, retest for SPN 651 – 658 FMI 18. Step 2. Determine if a base engine problem is causing fault code to become active. Decision. Using Electronic Service Tool (EST) with ServiceMaxx™ software, perform the following steps: Key ON, clear codes.Currently, have the code active for 1,3, and 5 injector.We have been to a couple cummins dealers, and none have been able to figure out the issue.Injector harness inside the engine, has been replaced, and all 6 injectors, have been replaced also, but still same issue. (Codes, I am getting are: SPN 655 FMI: 7/// SPN:653, FMI:7/// SPN: 651 …Feb 3, 2021 · SPN 656 / FMI 3 - EPA10 - GHG14 This diagnostic is typically Injector Cylinder #6 Needle Control Valve Abnormal Operation (MAX).This is normally a problem with number six injector. As long as the wiring and connector pins going to your injector from the ECM all check out good, replace the faulty injector. For further confirmation you could ... Feb 8, 2021 · Too low fuel, engine shakes first start and engine code on. Dec 4, 2018 · SPN 2659 FMI 18. Step 3 Verify Mass Air Flow (MAF) changes when Exhaust Gas Recirculation Valve (EGRV) is commanded ON. Decision Perform Air Management Test . Yes: End diagnostics, retest for SPN 2659 FMI 18. Does MAF signal decrease when EGR valve is 100% during test? No: Go to Step 4. Step 4 Verify EGRV can meet commanded position. Decision SPN 641 FMI 7 Refer to SNV14-003 for further information on procedures regarding SPN 641 FMI 7. Tags k21239812 spn 641 spn 641 fmi 7 volvo Related links and attachments No links or attachments available Feedback Give feedback to help improve the content of this article Internal Content ; Live UINo: Program ECM with most recent calibration. After repairs are complete, retest for SPN 651 – 658 FMI 18. Step 2. Determine if a base engine problem is causing fault code to become active. Decision. Using Electronic Service Tool (EST) with ServiceMaxx™ software, perform the following steps: Key ON, clear codes.3 SPN 652/FMI 4 - EPA10 - GHG14 This diagnostic is typically Injector Cylinder #2 Needle Control Valve Abnormal Operation (MIN). Table 6. SPN 652/FMI 4 Description Injector Cylinder #2 Needle Control Valve Abnormal Operation (MIN) Monitored Parameter Injector Cylinder #2 Needle Control Valve Typical Enabling Conditions Engine rpm = idle or higherDTC_FMI_EtcActuationFault 7 DTC_SPN_EtcPps1 65605 DTC_FMI_EtcPps1DataRx 12 DTC_FMI_EtcPps1VoltageHigh 3 DTC_FMI_EtcPps1VoltageLow 4 DTC_SPN_EtcPps12Correlation 65613 DTC_FMI_EtcPps12CorrelationFault 2 DTC_SPN_EtcPps2 65604 DTC_FMI_EtcPps2DataRx 12 DTC_FMI_EtcPps2VoltageHigh 3 DTC_FMI_EtcPps2VoltageLow 4 DTC_SPN_EtcReturn 65618 DTC_FMI ...SPN 656 FMI 6 Injector Driver #6 Short To Power 109 SPN 657 FMI 5 Injector Driver #7 Open/Short To Ground 111 SPN 657 FMI 6 Injector Driver #7 Short To Power 113 SPN 658 FMI 5 Injector Driver #8 Open/Short To Ground 115 SPN 658 FMI 6 Injector Driver #8 Short To Power 117 SPN 695 FMI 9 J1939 TSC1 Message Receipt Loss 296 ...It’s an SPN 656 . Return to Top | find. reply reply. 10-07-2020, (Subject: Engine fuel 1 injector cylinder 6 fmi 7 ) Post: #2. Godsplan15 Established (0 Likes)Jul 4, 2018 · SPN 656/FMI 6 - EPA10 - GHG14. Injector Cylinder #6 Needle Control Valve Shorted Circuit. 655/fmi 6. Injector Cylinder #5 Needle Control Valve Shorted Circuit. Good evening.looks like you have a injector or harness shorting out taking out the bank SPN:651 FMI:4 Injector 1 open coil - short circuit ... SPN:656 FMI:5 Injector 6 open coil - open circuit SPN:3659 FMI:4 Injector 1 close coil Œ short circuitSPN 190-FMI 7 Primary Speed/Timing Sensor Misinstalled. SPN 190-FMI 8 Primary Speed/Timing Signal Abnormal. Engine Speed Rate of Change ... SPN 656-FMI 5 Cylinder 6 Open. SPN 656-FMI 6 Cylinder 6 Short. SPN …ok, replaced #2, #6, injectors. reset trim codes, both original codes are still active, will not clear. tested harness under valve cover, found no issues with harness. 652-7, 656-7 still active. I used cat oem reman injectors.File: 656-t06-323 Page 1 of 10 ISX15 CM2250 Fault Code: 323 | SPN: 655 | FMI: 5 Injector Solenoid Driver Cylinder 5 Circuit - Current Below Normal or Open Circuit 1 Injector solenoid driver cylinder 5 current below normal or open circuit 1.1Injector solenoid circuit check at pass through connector 1.2Fuel injector solenoid has an open circuit2015 Volvo with ISX 15 engine I have issue with check engine light coming on for injectors spn 656 fmi 7 but when I changed the injector it just changed the code to spn653 fmi 7. At the beginning I ch … read more• SPN 4257 FMI 7 (INJ) Fault Facts • SPN 5395 FMI O and 1 (Engine) • SPN 3055 FMI 2 (INJ) • SPN 3480 FMI 3 and 4 ... (AFTFSV) • SPN 651 - 656 FMI 4 and • SPN 1322 - 1328 FMI 31 (Engine) • SPN 679 FM' 3 and 4 • SPN 2630 (CACOT) • SPN (IMT) • SPN 105 FM' 2, 172 ('AT) 3, and 4 • SPN 108 FM' 3 and 4 (BARO) • SPN 173 (EGT ...File: 656-t06-1438 Main lubricating oil pressure regulator is malfunctioning Page 9 of 11 Solution: S00000469 Verification Conditions • Turn keyswitch OFF. Action • Visually inspect the main lubricating oil pressure regulator assembly. Refer to Procedure 007-031 Specification • If any damage is found, then proceed to the Repair section.Feb 8, 2021 · Too low fuel, engine shakes first start and engine code on. The check engine light is back with 2 codes SA O/SPN 656/FMI 18 & SA 150/ SPN 524285/FMI 14. ... codes spn 6985 fmi 7, spn 84 fmi 19,4. spn 168 fmi 14,spn 158,fmi 2 ...DTC_SPN_InjEnbl6 656 DTC_FMI_InjEnblShortHigh 3 DTC_FMI_InjEnblShortLowOrOpen 5 DTC_SPN_InjEnbl7 657 DTC_FMI_InjEnblShortHigh 3 DTC_FMI_InjEnblShortLowOrOpen 5 ... DTC_FMI_Misfire 7 DTC_SPN_MisfireRandom 65599 DTC_FMI_Misfire 7 DTC_SPN_NonEtcTps 51 DTC_FMI_NonEtcTpsHigh 3 …a. If SPN fault code 168 or 723/FMI any is present, service those faults first. b. If SPN fault code 168 or 723/FMI any is NOT present, Go to step 2. 2. Check the warranty claim history. Check with driver. Is this the first occurrence of this fault within the last 30 days? a. Yes; Go to step 3. b.SPN 190-FMI 7 Primary Speed/Timing Sensor Misinstalled. SPN 190-FMI 8 Primary Speed/Timing Signal Abnormal. Engine Speed Rate of Change ... SPN 656-FMI 5 Cylinder 6 Open. SPN 656-FMI 6 Cylinder 6 Short. SPN 656-FMI 11 Cylinder 6 Fault. SPN 657-FMI 5 Cylinder 7 Open.SPN 656 FMI 5 Injector Driver #6 Open/Short To Ground 107 SPN 656 FMI 6 Injector Driver #6 Short To Power 109 SPN 657 FMI 5 Injector Driver #7 Open/Short To Ground 111 SPN 657 FMI 6 Injector Driver #7 Short To Power 113 SPN 658 FMI 5 Injector Driver #8 Open/Short To Ground 115 SPN 658 FMI 6 Injector Driver #8 Short To Power 117The FMI may also indicate that an abnormal operating condition has been detected. The codes are displayed in the form “SPN – FMI”. The ECM / ECU also attaches a text description to the message that is transmitted over the J1939 data link. This text description is used to describe the SPN – FMI. The failure mode of the DTC is determined ... To use the table below, first write down the SPN and FMI codes you received from the engine diagnostic gauge. Locate each SPN in the first column and its associated definition to the right in the second column. In the same way, locate the FMI in the forth column and its associated definition to the right in the fifth column. Spn 656 fmi 3? Detroit dd15 Freightliner Cascadea 2014. No, Experience: worked on, Gmc, Macks, Freight liner,Mercedes Benz,,Ford, sterling. Wayne is it fuel injector #6 a fail ?US10 Fault Codes , , , , SPN 651 FMI 3 SPN 651 FMI 5 SPN 652 FMI 3 SPN 652 FMI 5 SPN 653 FMI 3, , , , , SPN 653 FMI 5 SPN 654 FMI 3 SPN 654 FMI 5 SPN 655 FMI 3 SPN 655 FMI 5 SPN 656 FMI 3 SPN 656 FMI 5 SPN 641 , , , Fault code(s) Lights/Messages on information display message on display - - - - , - - / - - ,Freightliner Cascadia 2012 Detroit Engine DD15 ENG 2 SPN 3464 FMI 31 Throttle CMD, any idea what that code is for?Also, truck starts great but after idling for few minutes check engine light comes on ...SERIES 60 DDEC VI TROUBLESHOOTING GUIDE. 1.1 OVERVIEW. Detroit Diesel Corporation is the world leader in diesel engines and diesel engine electronics. DDC has made technological leaps in engine performance and fuel economy. Today, we build the most dependable electronically controlled diesel engine in the industry.Nov 4, 2021 · 2011 international pro star, engine code meanings, reset in active codes 1) spn 27 fmi 7 oc87 sa 0 conn --- pin N/A2) spn 3981 fmi 2 oc 1 sa 33 Con NA Pin3) spn 524285 fmi 14 oc 1 sa 150 con--- pin n/ … read more SPN 656 / FMI 3 - EPA10 - GHG14 This diagnostic is typically Injector Cylinder #6 Needle Control Valve Abnormal Operation (MAX).This is normally a problem with number six injector. As long as the wiring and connector pins going to your injector from the ECM all check out good, replace the faulty injector. For further confirmation you could ...a. If SPN fault code 168 or 723/FMI any is present, service those faults first. b. If SPN fault code 168 or 723/FMI any is NOT present, Go to step 2. WARNING: ENGINE EXHAUST To avoid injury from inhaling engine exhaust, always operate the engine in a well-ventilated area. Engine exhaust is toxic. WARNING: PERSONAL INJURY Spn 656 fmi 7
Detroit Diesel Ddec Vi Troubleshooting Guide Mbe4000 6se568 ... detroit-diesel656: 7: inj cylinder6 fuel flow lower than expected: 676: 3: glow plug relay stuck on: 676: 5: glow plug relay will not turn on: spn fmi description; 702: 14: speed (thrust mode) warning: 729: 3: ... spn fmi description; 1347: 5: fuel pump assy 1 ckt open, shorted ground or ovload: 1347: 7: fuel pump assy 1 rail pressure cont mismatch: 1347: 10 ...SPN 190-FMI 7 Primary Speed/Timing Sensor Misinstalled. SPN 190-FMI 8 Primary Speed/Timing Signal Abnormal. Engine Speed Rate of Change ... SPN 656-FMI 5 Cylinder 6 Open. SPN 656-FMI 6 Cylinder 6 Short. SPN 656-FMI 11 Cylinder 6 Fault. SPN 657-FMI 5 Cylinder 7 Open.spn 656 fmi 7 cummins also im getting bad mpg I get the same code, it comes and goes. I think there called ghost codes. My mileage sucks to, the best I've ever gotten out of my isx 15 is 6.8 and was running lite. When I'm heavy, 5.5. Diesel Dave, Nov 6, 2021Title: SPN 651 FMI 7- Injector 1 Spool Motion Compensation Max Authority Reached Applies To: 2013 OBD Maxxforce DT, 9, and 10 DESCRIPTION The engine operation break-in period for the injectors. During first this five time, hours fault of code SPN 651 FMI are 7 considered may s t. This as code a may or may not be true.SPN 190-FMI 7 Primary Speed/Timing Sensor Misinstalled. SPN 190-FMI 8 Primary Speed/Timing Signal Abnormal. Engine Speed Rate of Change ... SPN 656-FMI 5 Cylinder 6 Open. SPN 656-FMI 6 Cylinder 6 Short. SPN 656-FMI 11 Cylinder 6 Fault. SPN 657-FMI 5 Cylinder 7 Open.It is showing code SPN-656 and SPN-655. 2014 Freightliner Cascadia 125. The truck - Answered by a verified Technician. We use cookies to give you the best possible experience on our website. ... SPN 656/FMI 6 - EPA10 - GHG14. Injector Cylinder #6 Needle Control Valve Shorted Circuit.SPN:656 FMI:5 Injector 6 open coil - open circuit SPN:3659 FMI:4 Injector 1 close coil Œ short circuit SPN:3659 FMI:5 Injector 1 close coil Œ open circuit SPN:3660 FMI:4 Injector 2 close coil - short circuit SPN:3660 FMI:5 Injector 2 close coil - open circuitDiesel Technician. Vocational, Technical or Tra... 16 satisfied customers. Peterbilt 389 throwing these codes: SPV 2791, 1781, 3821, Peterbilt 389 throwing these codes: SPV 2791, 1781, 3821, 2795, 2795, 2795, 5246. wanting to know how to fix these … read more.May 22, 2019 · FAULT CODE FMI DESCRIPTION FIRST DETECTED LAST OBSERVED TYPE SPN-651 7 Engine Fuel 1 Injector Cylinder 1 Nov 15, 4:17 AM Nov 15, 4:59 PM Constant SPN-652 7 Engine Fuel 1 Injector Cylinder 2 Nov 14, 6:32 PM Nov 15, 4:59 PM Constant SPN-653 7 Engine Fuel 1 Injector Cylinder 3 Nov 14, 1:56 PM Nov 15, 4:59 PM Constant SPN-655 7 Engine Fuel 1 Injector Cylinder 5 Nov 14, 11:38 PM Nov 15, 4:59 PM ... This spn fmi codes help explain the underlying meaning of the numerical components which build an engine fault code. - This is not a comprehensive list, or an alternative to the …Detroit Diesel Ddec Vi Troubleshooting Guide Mbe4000 6se568 ... detroit-dieselDESCRIPTION This document will guide the user through correctly diagnosing fuel injector circuit faults on 2010 Maxxforce DT, 9, 10 and 2014 N9, N10 engines. SYMPTOM(s) Diagnostic Trouble Code(s) & Dashboard Indicator Light(s): SPN:3664 FMI:5 Injector 6 close coil - open circuit1.2 scope and use of this guideI have a 2010 International with an ISM cummins. The truck is intermediately throwing a spn 641 fmi 7 code. This code leads to the vgt turbo actuator. Mechanic I took it to says to just replace the entire turbo at 3k plus labor. Says he hasn't had any luck replacing the actuator by itself and a new turbo comes with the actuator installed already.Spn 636/Fmi 7. 213. Camshaft and Crankshaft Signals Not Matching. 213. ... Spn 656/Fmi 5. 251. Spn 656/Fmi 10. 254. SPN 701-Jake Brakes Low (Aux PWM #7) Open or Short ...spn 656 fmi 7 cummins also im getting bad mpg I get the same code, it comes and goes. I think there called ghost codes. My mileage sucks to, the best I’ve …19 thg 6, 2015 ... SPN 655 SPN 655/FMI 6 Injector Cylinder #5 Control Valve Circuit Shorted to Battery<br />. SPN 656 SPN 656/FMI 6 Injector Cylinder #6 Control ...DTC_SPN_InjEnbl6 656 DTC_FMI_InjEnblShortHigh 3 DTC_FMI_InjEnblShortLowOrOpen 5 DTC_SPN_InjEnbl7 657 DTC_FMI_InjEnblShortHigh 3 DTC_FMI_InjEnblShortLowOrOpen 5 ... DTC_FMI_Misfire 7 DTC_SPN_MisfireRandom 65599 DTC_FMI_Misfire 7 DTC_SPN_NonEtcTps 51 DTC_FMI_NonEtcTpsHigh 3 …SPN 91, FMI 3 - FPP1 Voltage High F. Page 295 and 296: SPN 520199, FMI11 - FPP2 Invalid Vo. Page 297 and 298: SPN 91, FMI 16 - FPP1 Higher than F. Page 299 and 300: SPN 29, FMI 4 - FPP2 voltage low FP. Page 301 and 302: SPN 51, FMI 31 - TPS1/2 Simultaneou. Page 303 and 304: SPN 108, FMI 0 -BP High Pressure . Page 305 …SPN 656-FMI 5 Cylinder 6 Open. SPN 656-FMI 6 Cylinder 6 Short. SPN 656-FMI 11 Cylinder 6 Fault. SPN 657-FMI 5 Cylinder 7 Open. SPN 657-FMI 6 Cylinder 7 Short. LDGCP and MGCP header pins are in standard font, HDGCP and MDGCP header pins are in italicized parentheses (##). 7.1 SPN & FMI to DTC Conversion Table ... 656. 5 ...File: 656-t06-3616 Page 1 of 6 ISX15 CM2250 Fault Code: 3616 | SPN: 2633 | FMI: 7 Engine VGT Nozzle Position - Mechanical System Not Responding or Out of Adjustment 1 Check for primary fault codes 2 Incorrect variable geometry turbocharger actuator installation 2.1Variable geometry turbocharger actuator calibration incorrectSPN 656, FMI 6 - Injector Driver #6. Page 107 and 108: SPN 657, FMI 5 - Injector Driver #7. Page 109 and 110: SPN 657, FMI 6 - Injector Driver #7. Page 111 and 112: SPN 658, FMI 5 - Injector Driver #8. Page 113 and 114: SPN 658, FMI 6 - Injector Driver #8. Page 115 and 116: 2) Emissions are higher than allowe.SPN 654 FMI 5 - Cummins FC 332 Injector solenoid driver cylinder 4 circuit current below normal or open circuit SPN 655 FMI 5 - Cummins FC 323 Injector solenoid driver cylinder 5 circuit current below normal or open circuit IK1201447 -Cummins B6.7 Injector Short Circuit Page 1 of 2FAULT CODE FMI DESCRIPTION FIRST DETECTED LAST OBSERVED TYPE SPN-651 7 Engine Fuel 1 ... 11:38 PM Nov 15, 4:59 PM Constant SPN-656 7 Engine Fuel 1 Injector Cylinder 6 Nov 15, 10:31 AM Nov 15, 4:59 ... I have a 2013 Freightliner vin 1fujghdv0dsfa0570.Codes spn 3361 fmi 7 Spn 4335 fmi 14Also codes 5246 fmi 15 and …Nich1019. Vocational, Technical or Tra... I have some indications. 2014 internation Prostar. 700 k. FAULT CODE FMI DESCRIPTION FIRST DETECTED LAST OBSERVED TYPE SPN-651 7 Engine Fuel 1 Injector Cylinder 1 Nov 15, 4:17 AM … read more.Feb 8, 2021 · Too low fuel, engine shakes first start and engine code on. Perform Injector Test (page 1415). Yes: Perform appropriate SPN 651 - 656 FMI 4 or 5 and SPN 3659 - 3664 FMI 4 or 5 diagnostics to identify failure. Repair as needed. After repairs are complete, retest for SPN 1322 FMI 31. Was a …Transcript. Code Description of the Code E048 Backup ECM Took Control E881 Multiple Master Control Stations CID 253-FMI 2 Check Customer or System Parameters CID 254-FMI 12 ECM Fault CID 268-FMI 2 System Parameters CID 337-FMI 2 Incorrect Remote E-Stop Switch Inputs CID 338-FMI 5 Pre-Lube Relay Open Circuit CID 338-FMI 6 Pre-Lube …Section 63SPN 656. This SPN indicates the injector #6 cylinder needle control valve is not operating normally.. 63.1 SPN 656/FMI 14. EPA07 DD15 Troubleshooting Guide - DDC-SVC-MAN-0029. Generated on 10-13-2008. Posted in DD15 Troubleshooting.SPN 629 FMI 8 OC 1 SA 0; SPN 652 FMI 14 OC 2 SA 0; SPN 656 FMI 14 OC 2 SA 0; SPN 2659 FMI 21 OC 61 SA 0; SPN 2659 FMI 10 OC 1 SA 0. believe two codes 652 and 656 from changing fuel filter yesterday and having a little air let in system. but not sure. Technician: Alex Olsen, replied 3 years ago. 652 and 656 are injector timing/fuel …File: 656-t06-2398 Page 1 of 7 ISX15 CM2250 Fault Code: 2398 | SPN: 171 | FMI: 2 Ambient Air Temperature - Data Erratic, Intermittent, or Incorrect 1 Check for primary fault codes 2 Intake manifold temperature sensor stuck in-range 3 OEM ambient air temperature sensor stuck in-range 4 Ambient air temperature sensor open circuit checkApr 4, 2019 · Medium and Heavy Trucks. I have Volvo VNL 670, 2011, D13. I have a code SPN 2659 FMI…. This fault is for egr cooler low flow. What is usually done is to run the egr valve test with ptt and see if the flow reaches at least .3. If it does not it is either a plugged egr cooler or an issue with plugged ports on the egr diff pressure sensor. File: 656-t06-1438 Main lubricating oil pressure regulator is malfunctioning Page 9 of 11 Solution: S00000469 Verification Conditions • Turn keyswitch OFF. Action • Visually inspect the main lubricating oil pressure regulator assembly. Refer to Procedure 007-031 Specification • If any damage is found, then proceed to the Repair section.It is showing code SPN-656 and SPN-655. 2014 Freightliner Cascadia 125. The truck - Answered by a verified Technician. We use cookies to give you the best possible experience on our website. ... SPN 656/FMI 6 - EPA10 - GHG14. Injector Cylinder #6 Needle Control Valve Shorted Circuit.a. If SPN fault code 168 or 723/FMI any is present, service those faults first. b. If SPN fault code 168 or 723/FMI any is NOT present, Go to step 2. 2. Check the warranty claim history. Check with driver. Is this the first occurrence of this fault within the last 30 days? a. Yes; Go to step 3. b.Jun 13, 2018 · SID, PID FMI SPN Imf Description; 111 Red: ... 656 5 № Nozzle Control Valve chain 6-chain breakage: 328 Yellow: S152 7: 1348 7: Injection VALVE № 2 pump ... The truck is a 2010 International 8600 that has been deleted and throwing a spn 641 fmi 7 code which points to the VGT actuator. The tech who deleted it said to just replace the entire turbo charger as he hasn't had much luck just changing the actuator and reprograming it with the old turbocharger. Guess the new turbocharger comes with the ...SPN 1274, FMI 5 - Spark Coil #7 Pri. Page 13 and 14: (Industrial, Smart/Logic Coil) LED . Page 15 and 16: 2nd Page of Diagnostic Information . Page 17 and 18: Resetting active and previously act. ... SPN 656, FMI 6 - Injector Driver #6; Page 107 and 108: SPN 657, FMI 5 - Injector Driver #7;START NOW. SPN 656, FMI 5 - Injector Driver #6 Open/Short-To-Ground. • Injector #6 (FO) Coil or Driver Open Circuit or Short-to-Ground. • Check Condition-Key-On, Engine Running. • Fault Condition-Battery voltage at ECM greater than x volts and injector low-side less than y. volts for z injector firings as defined in the diagnostic ...a. If SPN fault code 168 or 723/FMI any is present, service those faults first. b. If SPN fault code 168 or 723/FMI any is NOT present, Go to step 2. WARNING: ENGINE EXHAUST To avoid injury from inhaling engine exhaust, always operate the engine in a well-ventilated area. Engine exhaust is toxic. WARNING: PERSONAL INJURYOct 22, 2023 · It’s an SPN 656 . Return to Top | find. reply reply. 10-07-2020, (Subject: Engine fuel 1 injector cylinder 6 fmi 7 ) Post: #2. Godsplan15 Established (0 Likes) File: 656-t06-18835 Aftertreatment DPF differential pressure sensor circuit pin to ground short Page 7 of 10 Solution: S00001539 Verification Conditions • Turn keyswitch OFF. • Disconnect the OEM wiring harness connector from the ECM. • Disconnect the aftertreatment DPF differential pressure sensor from the OEM wiring harness. ActionSPN 1327, FMI 31 - Emissions/Catalyst Damage Misfire Detected . Cylinder #5 . Diagnostic Aids . NOTE: If any other DTCs are present, diagnose those first. ... 104 SPN 656, FMI 6 - Injector Driver #6 Short-To-Power; 105 SPN 656, FMI; 106 SPN 657, FMI 5 - Injector Driver #7 Open/Short-To-Ground;Spn 656 fmi 3? Detroit dd15 Freightliner Cascadea 2014. No, Experience: worked on, Gmc, Macks, Freight liner,Mercedes Benz,,Ford, sterling. Wayne is it fuel injector #6 a fail ?Maxxforce DTCs. 2012 Maxxforce 10, EPA 2010, EGR and DPF Deleted. This engine is in an RV. Throwing SPN 3480 FMI 3, and SPN 5456 FMI 3. Problem was intermittent until last week, now it throws the codes on almost every drive cycle. I have followed Navistar diagnostics for AFTIS.File: 656-t06-1963 Page 1 of 9 ISX15 CM2250 Fault Code: 1963 | SPN: 3482 | FMI: 7 Aftertreatment Fuel Shutoff Valve - Mechanical System Not Responding or Out of Adjustment 1 Check for primary fault codes 2 Low pressure fuel system component is malfunctioning 2.1Air in fuel check 2.2Fuel Inlet Restriction check 2.3Fuel lift pump checkView and Download Detroit Diesel Series 60 DDEC VI troubleshooting manual online. Series 60 DDEC VI engine pdf manual download. RE: SA 0 SPN 641 FMI 7/ SA 0 SPN 641 FMI 13. On quickserv, SPN641, FMI7 comes up as ... Cummins Fault Code 2387 - VGT Actuator Driver Circuit (Motor) - Mechanical System Not Responding or Out of Adjustment. The smart VGT controller has detected incorrect stop limits, or the VGT is unable to move to the closed position.SPN FMI ACM2.1 FAULT CODE DESCRIPTION GHG14 108 13 Ambient Air Pressure Signal Not Available via CAN 110 9 Coolant Temperature Signal Not Available via CAN 158 7 ACM Power Down - Key Off Purge Cycle 168 0 Battery Voltage High 168 1 Battery Voltage Low 171 13 Ambient Air Temperature Signal Not Available via CANHave an spn 656 fmi 7 code. changed #6 injector and #6 exhaust rocker. passees injector buz test and injector cutout - Answered by a verified Technician.102 SPN 656, FMI 5 - Injector Driver #6 Open/Short-To-Ground; 103 SPN 656, FMI; 104 SPN 656, FMI 6 - Injector Driver #6 Short-To-Power; 105 SPN 656, FMI; 106 SPN 657, FMI 5 - Injector Driver #7 Open/Short-To-Ground; 107 SPN 657, FMI; 108 SPN 657, FMI 6 - Injector Driver #7 Short-To-Power; 109 SPN 657, FMI; 110 SPN 658, FMI 5 - Injector Driver .... Dinar opinion.com